DC-DC聽10-60V聽to聽12-97V聽1500W聽30A聽Voltage聽Step聽Up聽Converter聽Boost聽CC聽CV聽Power聽Supply聽Module聽

Features:

This聽is聽a聽non-isolated聽DC聽power聽converter聽module聽with聽long聽service聽life.
High聽power聽and聽stable聽output,聽it聽converts聽10-60VDC聽to聽12-97VDC.
High聽quality聽components聽ensures聽high聽conversion聽efficiency,聽up聽to聽97%

Designed聽with聽smart聽temperature聽control聽fan,聽which聽will聽automatically聽work聽when聽temperature聽reaches聽about聽60鈩?聽and聽stop聽when聽temperature聽drops聽below聽60鈩?
Widely聽used聽for聽high聽power聽solar聽street聽lamp聽driving,聽various聽LED聽lighting聽CV聽driving,聽vehicle-mounted聽and聽mobile聽device聽power聽supply,聽DIY聽adjustable聽CV聽CC聽power聽supply,聽solar聽power聽charging,聽and聽various聽batteries聽charging.

Specification:
聽Name:聽1500W聽step聽up聽constant聽current聽module
聽Type:聽Non-isolated聽step-up聽module聽(BOOST)
聽Input聽Voltage:聽DC10V聽to聽60V
聽Input聽Current:聽10V-30V聽input聽voltage,聽maximum聽current聽is聽35A-40A;聽31-60V聽input聽voltage,聽maximum聽current聽is聽30A-35A
聽Quiescent聽Current:聽15mA(when聽convert聽12V聽to聽20V,聽higher聽output聽voltage聽will聽increase聽quiescent聽current)
聽Output聽Voltage:聽12-97V聽continuously聽adjustable聽(cannot聽be聽used聽to聽step聽down聽voltage)
聽Output
聽Current:聽22A聽(related聽to聽the聽input聽and聽output聽voltage聽difference,聽the聽
greater聽voltage聽difference聽is,聽the聽smaller聽output聽current聽will聽be.聽
please聽enhance聽heat聽dissipation聽when聽current聽is聽over聽15A)
聽Constant聽Current聽Range:聽0.8-22A(+/-0.3A)
聽Reverse聽Input聽Protection:聽Yes聽(150A聽power聽MOS聽reverse聽protection)
聽Input聽Low聽Voltage聽Protection:聽Yes聽(10V-50V聽adjustable,聽self-recovery)
聽Operating聽Temperature:聽-40鈩兟爐o聽85鈩?if聽temperature聽is聽too聽high,聽please聽enhance聽heat聽dissipation)
聽Frequency:聽150KHz
聽Conversion
聽Efficiency:聽92%聽to聽97%聽(Efficiency聽is聽related聽to聽input/output聽voltage,聽
current聽and聽voltage聽difference.聽The聽smaller聽difference聽is,聽the聽higher聽
efficiency聽will聽be)
聽Input聽Over聽Current聽Protection:聽Yes聽(automatically聽protect聽when聽input聽is聽more聽than聽40A,聽and聽power聽supply聽voltage聽will聽not聽increase)
聽Short聽Circuit聽Protection:聽Yes聽(input聽60A聽fuse)聽please聽operate聽carefully,聽try聽not聽to聽cause聽short聽circuit.
聽Reverse聽Input聽Protection:聽Yes聽((150A聽power聽MOS聽tube,聽can聽be聽connected聽reversely聽for聽long聽time)
聽Installation聽Method:聽Four聽3mm聽standoffs
聽Wiring聽Method:聽Terminal聽blocks聽(Please聽use聽large聽current聽copper聽wire)
聽Output聽Power:聽Maximum聽Output聽Power聽=聽Input聽Voltage*30A(If聽input聽12V,聽the聽maximum聽output聽power=12V*30A聽=聽360W)
聽(If聽input聽24V,聽the聽maximum聽output聽power=24V*30A聽=聽720W)
Weight:聽372g聽/聽13.1oz聽(approx.)
Package聽list:
1聽*聽Module
Instructions:
聽Module
聽output聽should聽not聽short聽circuit聽or聽measure聽current聽directly聽聽with聽
multimeter聽short聽circuit,聽short聽circuit聽will聽burn聽out聽module.
聽Under聽
voltage聽adjustable聽range:DC10V-50V聽(clockwise聽to聽increase,聽
counterclockwise聽to聽reduce),聽firstly聽adjust聽under-voltage聽to聽the聽
minimum,聽then聽adjust聽input聽voltage聽to聽required聽under-voltage聽protection聽
value,聽slowly聽adjust聽under-voltage聽value聽clockwise聽to聽increase;聽when聽the
聽under-voltage聽light聽is聽on,聽adjust聽counterclockwise聽of聽one聽circle,聽then聽
power聽on聽again.聽
聽Input聽under-voltage聽protection聽mainly聽used聽to聽
prevent聽battery聽from聽over-discharging聽when聽input聽power聽source聽is聽
battery.聽Low聽battery聽voltage聽will聽damage聽power聽module聽and聽battery.聽When聽
input聽is聽switching聽power聽supply,聽it聽also聽need聽to聽set聽the聽low聽voltage聽
protection.
聽Constant聽voltage聽adjustable聽range:DC12-97V(clockwise聽to聽
increase,聽counterclockwise聽to聽reduce),聽first聽adjust聽voltage聽to聽the聽
required聽voltage聽and聽then聽connected聽to聽the聽load.
聽Constant聽current聽
adjustable聽range:0.8-22A聽(clockwise聽to聽increase聽and聽counterclockwise聽to聽
reduce),聽first聽disconnect聽load,聽then聽adjust聽output聽voltage聽to聽required聽
voltage,聽adjust聽current聽to聽the聽minimum聽(counterclockwise聽turn聽CC聽
potentiometer聽about聽30聽circles),聽connect聽an聽ammeter聽in聽series聽to聽the聽
output,聽then聽slowly聽adjust聽current.(boost聽motor聽module聽cannot聽directly聽
adjust聽current聽by聽short聽circuit)
聽Input聽voltage聽should聽not聽be聽lower聽
than聽10V聽or聽higher聽than聽60V,聽(when聽input聽voltage聽is聽lower聽than聽12V,聽
please聽properly聽reduce聽the聽load).
聽Make聽sure聽the聽input聽voltage聽is聽at聽lease聽2V聽lower聽than聽output聽voltage.聽
聽If
use聽switching聽power聽supply聽or聽other聽secondary聽power聽supply,聽please聽make
聽sure聽that聽power聽is聽1.3聽times聽greater聽or聽more聽than聽the聽power聽supply聽
module's聽power.
聽During聽over聽current聽or聽under-voltage聽protection,聽
output聽will聽still聽have聽voltage聽that聽is聽close聽to聽the聽input聽voltage,聽
protection聽means聽no聽boosting聽voltage.